Author Topic: Checking 98EV TPS  (Read 823 times)

Offline steven c

  • Gaggle Hero
  • *****
  • *
  • *
  • Posts: 4145
  • Location: Broad Brook CT
Checking 98EV TPS
« on: May 27, 2020, 10:43:08 AM »
 Is their a tutorial on how to check and set the TPS for a 98 EV? I know you check the voltage but where are you checking it from? I can't find anything specific.
2020 V85TT Traveler
74 949 Eldorado


75 Benelli 250
2006 Buell Ulysses
78 Honda XL125

MGNOC 6412

Offline steven c

  • Gaggle Hero
  • *****
  • *
  • *
  • Posts: 4145
  • Location: Broad Brook CT
Re: Checking 98EV TPS
« Reply #1 on: May 27, 2020, 10:48:40 AM »
 I did find this after googling a couple different ways.
http://bradthebikeboy.blogspot.com/2012/10/throttle-position-sensor-setting_21.html
2020 V85TT Traveler
74 949 Eldorado


75 Benelli 250
2006 Buell Ulysses
78 Honda XL125

MGNOC 6412

Online antmanbee

  • Gaggle Mentor
  • ****
  • Posts: 903
  • Location: N E Florida
Re: Checking 98EV TPS
« Reply #2 on: May 27, 2020, 10:51:03 AM »
Those are good instructions to follow.

Offline pehayes

  • Gaggle Hero
  • *****
  • *
  • *
  • *
  • *
  • *
  • Posts: 4570
    • Falcone Touring
Re: Checking 98EV TPS
« Reply #3 on: May 27, 2020, 10:56:40 AM »
I'll have to dig out the details and post a little later.  I disassemble the cover from the master gang plug on the P8 CPU.  Unplug the gang connector, remove Phillips screw at the end, slide the cover off, carful to catch and retain the plastic slide guides, search for numbers on the various connections.  I then use 'T-Pins' to probe into two of the wires.  Set up volt meter and turn key to ON but not start.  Meter reads millivolts.  With all linkages disconnected, the base installation reading should be 150mV.  Reconnect the linkage, adjust for balance and idle, TPS should now read about 385mV.  Here are some old files and not quite so good pictures:











OR, forget all that and install GuzziDiag on an old laptop and get the data read-out that way.

Patrick Hayes
Fremont CA

Wildguzzi.com

Re: Checking 98EV TPS
« Reply #3 on: May 27, 2020, 10:56:40 AM »

Offline JoeB

  • Gaggle Mentor
  • ****
  • Posts: 849
  • Location: NWPA
Re: Checking 98EV TPS
« Reply #4 on: May 27, 2020, 01:54:19 PM »
Here's another to check out: https://archive.guzzitech.com/Bassa_TPS_Arimoto.pdf

Edit: the instructions posted by OP is noting to set TPS 486-528mv after baseline setting.
This, I think, is true for later models.
 However like pehayes mentions on the 98 it should be in the 385mv ballpark.
« Last Edit: May 27, 2020, 02:02:30 PM by JoeB »
It ain't what they call you, it's what you answer to.

Offline steven c

  • Gaggle Hero
  • *****
  • *
  • *
  • Posts: 4145
  • Location: Broad Brook CT
Re: Checking 98EV TPS
« Reply #5 on: May 27, 2020, 02:18:06 PM »
Great thank you. 


2020 V85TT Traveler
74 949 Eldorado


75 Benelli 250
2006 Buell Ulysses
78 Honda XL125

MGNOC 6412

Offline JoeB

  • Gaggle Mentor
  • ****
  • Posts: 849
  • Location: NWPA
Re: Checking 98EV TPS
« Reply #6 on: May 27, 2020, 05:47:32 PM »
Found another one, actually the one I was originally looking for: https://archive.guzzitech.com/EVTuneup-Jeff_B.html
And the factory workshop manual, look around page 15.
https://dpguzzi.com/efiman.pdf
good luck
It ain't what they call you, it's what you answer to.

Offline Wayne Orwig

  • Gaggle Hero
  • *****
  • Posts: 13908
    • Hog Mountain weather
  • Location: Hog Mountain
Re: Checking 98EV TPS
« Reply #7 on: May 28, 2020, 07:46:11 AM »
The later model EV, the Jackal, and I believe all Bassa's, use the 15M ECU. The 98 EV uses the P8 ECU, (large box under the rear seat).
Setting the TPS is almost identical, except the voltage. The P8 is set to 2.1 degrees, or about 365 - 385 mv. The 15M is set to 3.6 degrees, or about 524 mv.
Also, the idle air screws on the P8 are usually 1 turn out, and on the 15M 1/2 turn out.
« Last Edit: May 28, 2020, 07:49:44 AM by Wayne Orwig »
Scientist have discovered that people will believe anything, if you first say "Scientists have discovered...."

Offline Rich A

  • Gaggle Hero
  • *****
  • *
  • *
  • *
  • Posts: 3151
Re: Checking 98EV TPS
« Reply #8 on: May 28, 2020, 11:01:39 AM »
Check the fitment, but one of these (or something similar) makes it easier to check the TPS. I struggled to get straight pins to make contact thru the connector.

https://www.amazon.com/109172-TPS-Breakout-Dense-Metripack/dp/B014TKDYHC

Rich A

Offline Tom H

  • Gaggle Hero
  • *****
  • *
  • *
  • *
  • *
  • *
  • Posts: 3377
  • Location: So. Cal.
Re: Checking 98EV TPS
« Reply #9 on: May 28, 2020, 11:14:57 AM »
I bought one of those adapters, well worth it in my opinion. I bought it direct, I thought I paid about $15?

The instructions by Jeff B is what I use. Easy to follow. I printed that out. I do also have the Efiman as well.

Tom
2004 Cali EV Touring
1972 Eldo
1970 Ambo V1000
1973 R75/5 SWB with Toaster
2007 HD Street Bob
1953 Triumph 6T (one day it will be on the road!)

***Wildguzzi Official Logo High Quality 5 Color Window Decals Back In Stock***
Shipping in USA Only. Awesome quality. Back by popular demand. All proceeds go back into the forum.
http://www.wildguzzi.com/Products/products.htm
Advertise Here
 

20 Ounce Stainless Steel Double Insulated Tumbler
Buy a quality tumbler and support the forum at the same time!
Better than a YETI! BPA and Lead free.
Advertise Here