General Category > Bike Builds, Rebuilds And Restorations Only
69 Ducati 450 Jupiter Resto
Antietam Classic Cycle:
--- Quote from: Scout63 on January 07, 2023, 07:39:26 AM ---I pulled the muffler. There is nothing left inside it. Now to source a replacement. In the process of pulling the countersprocker cover I snapped off the adjuster screw below the shift lever. I thought it had to come out but it didn’t. Front tire mounted.
--- End quote ---
It it this one?: https://motostoricheitaliane.com/scarichi-moto-marmitte-moto-d-epoca/ricambi-ducati-scrambler-450-mark/
Scout63:
I ordered this one Charlie. I’m not sure if they are the same:
https://www.officine08.com/p11323_exhaust-muffler-ducati-450-scrambler-busso-chrome-short.html
Front wheel is cleaned up and back on. Clutch cover off. Needs new friction plates. The crank gear and clutch basket look good. I’m wiring the bike and installing electronic ignition and 12v rotor/stator/regrec all at the same. What could possibly go wrong.
Scout63:
New rotor and stator installed. Electronic ignition installed and timed. Reg/rec mounted on skid plate. Mostly wired. I just need to wire in the new left switch assembly and then loom everything. Wiring is basically a headlight bucket toggle switch to engage the Fuzeblock, and another headlight bucket toggle switch to turn on lights. The bike has great compression. I needed the decomp lever just to be able to rotate the crank with the piston stop in place.
Canuck750:
Nice electronic upgrades, that fuse block looks slick.
Which brand of reg/rec did you use?
Scout63:
--- Quote from: Canuck750 on January 15, 2023, 07:50:04 PM ---Nice electronic upgrades, that fuse block looks slick.
Which brand of reg/rec did you use?
--- End quote ---
It came as part of the 12v rotor/stator kit from Electrex in the UK:
https://www.electrexworld.co.uk/acatalog/STK-163.html
I have a lithium battery in it that needs a lower charge point. I’m going to watch the voltage carefully and maybe switch to an AGM battery. Here’s the Fuzeblock link. They make wiring neat and allow you to energize everything with one switch:
https://www.fuzeblocks.com/Fuzeblocks-FZ-1-Distribution-Block_p_1.html
Navigation
[0] Message Index
[#] Next page
[*] Previous page
Go to full version