Wildguzzi.com

General Category => General Discussion => Topic started by: Huzo on August 27, 2016, 07:57:21 PM

Title: 07 Norge oil temp thermostat
Post by: Huzo on August 27, 2016, 07:57:21 PM: Does my '07 Norge have a oil TEMPERATURE thermostat ?
Title: Re: 07 Norge oil temp thermostat
Post by: MAC on August 27, 2016, 08:23:33 PM: Quote from: Huzo on August 27, 2016, 07:57:21 PM
Does my '07 Norge have a oil TEMPERATURE thermostat ?
Yes, inboard the right cylinder.Check for broken sensor support.
Oil temperature sensor part#29729461
Sensor support part#03163330

http://www.harpermoto.com/parts-by-motorcycle/2000-up-moto-guzzi-motorcycles/norge-1200-ie-1200-2006-2008/electrical-system-i-en-norge-1200-ie-2006-2008.html
Title: Re: 07 Norge oil temp thermostat
Post by: Bisbonian on August 27, 2016, 11:23:58 PM: Sensor and thermostat are two different things.

I don't think the 2 valve engines have a thermostat.

Not 100% sure though.
Title: Re: 07 Norge oil temp thermostat
Post by: Huzo on August 28, 2016, 12:37:18 AM: Yes the diagram shows part# 25 as oil temp sensor, but as far as I can tell no pressure sensor., however I know the pressure sensor exists 'cos I've replaced it once and it comes on before start up and immediately goes out when running, there's been a lot said about them here. Also where does the air temp sensor mount ? Mine has always sorta just hung on the harness inside the fairing. There's nothing amiss, just wondered. Thanks, Huzo.
Title: Re: 07 Norge oil temp thermostat
Post by: Phang on August 28, 2016, 02:57:54 AM: 2V Norge has a oil thermostat

(https://www.harpermoto.com/images/pl/2000/norge%201200%20ie%201200%202006-2008/images/engine-oil-filters.jpg)

Part #5 in the diagram
Title: Re: 07 Norge oil temp thermostat
Post by: pete roper on August 28, 2016, 04:52:45 AM: Phang nails it! (Greetings from Ireland my friend!)

Pete
Title: Re: 07 Norge oil temp thermostat
Post by: Huzo on August 28, 2016, 12:47:32 PM: Yep, nailed it indeed! Thanks Phang and Peter.
Title: Re: 07 Norge oil temp thermostat
Post by: tris on August 28, 2016, 02:30:58 PM: Quote from: Huzo on August 28, 2016, 12:37:18 AM
....... Also where does the air temp sensor mount ? ......

If its the same as my Breva the ECU air temperature sensor mounts into the air box on the right side
Title: Re: 07 Norge oil temp thermostat
Post by: Idontwantapickle on August 28, 2016, 02:55:29 PM: Quote from: Huzo on August 28, 2016, 12:37:18 AM
Also where does the air temp sensor mount ? Mine has always sorta just hung on the harness inside the fairing. There's nothing amiss, just wondered. Thanks, Huzo.

I think you are describing the ambient air temp sensor for the dash display.
Hunter
Title: Re: 07 Norge oil temp thermostat
Post by: Huzo on August 29, 2016, 01:13:46 AM: Quote from: Idontwantapickle on August 28, 2016, 02:55:29 PM
I think you are describing the ambient air temp sensor for the dash display.
Hunter
Bingo !!!! Any ideas ?
Title: Re: 07 Norge oil temp thermostat
Post by: rodekyll on August 29, 2016, 03:16:07 AM: It just needs to be in the air somewhere, preferably not too close to the engine. Where doesn't really matter to the sensor, as long as it can measure outside air. If it bothers you hanging there, zip tie it or thread it around to somewhere else.

As to the 'proper' place -- don't know.
Title: Re: 07 Norge oil temp thermostat
Post by: tris on August 29, 2016, 02:10:04 PM: Doh - answered the wrong question :embarrassed:

The dash temp sensor is mounted at the left hand end of the little panel that carries the 4 way flashers and ABS switches
Title: Re: 07 Norge oil temp thermostat
Post by: ITSec on August 29, 2016, 04:07:08 PM: Quote from: Phang on August 28, 2016, 02:57:54 AM
2V Norge has a oil thermostat

(https://www.harpermoto.com/images/pl/2000/norge%201200%20ie%201200%202006-2008/images/engine-oil-filters.jpg)

Part #5 in the diagram

I may be wrong (happens at least once every few years), but that part looks an awful lot like an oil pressure valve and not a thermostat. I know how it's labeled in the parts diagram, but this is from a company that still has trouble identifying a transmission in a manner that most people understand. :laugh:
Title: Re: 07 Norge oil temp thermostat
Post by: pete roper on August 29, 2016, 04:11:38 PM: Nope, it's the thermo. The OPRV is next to it
Title: Re: 07 Norge oil temp thermostat
Post by: Huzo on August 30, 2016, 01:21:46 AM: Quote from: rodekyll on August 29, 2016, 03:16:07 AM
It just needs to be in the air somewhere, preferably not too close to the engine. Where doesn't really matter to the sensor, as long as it can measure outside air. If it bothers you hanging there, zip tie it or thread it around to somewhere else.

As to the 'proper' place -- don't know.
Yeah reasonable comment, I just couldn't find an appropriate spot within the range of the harness. But thanks for the help.